Multiquip MQ62TKT Trash Pump, 6", Trailer Mount 28 GAL, 1,190 GPM, KOHLER KDW 1404 Tier 4 Final Diesel Engine

Multiquip MQ62TKT Trash Pump, 6", Trailer Mount 28 GAL, 1,190 GPM, KOHLER KDW 1404 Tier 4 Final Diesel Engine • Pumps up to 1,190 gallons per minute. • Maximum head rated 111 feet. • Powered by KOHLER Tier 4 Final 4-cylinder, diesel engine. • Engine incorporates a water/fuel separation filtration system. • Full featured, shock mounted LOFA EL240 Control Panel. • Industrial DOT/NHTSA approved single-axle trailer. • 28-gallon fuel cell. • Pump-end supplies large cleanout cover • 6” Male NPT Threaded Suction/Discharge ports. • Wear-resistant ductile cast iron volute and impeller assembly. • Stainless steel wear plate. • Integrated lifting bale. • Abrasion-resistant, oil lubricated tungsten/carbide seal system. • Pumps solids up to 3 inches in diameter. • Approximate running time of 15 hours.

Multiquip MQ62TKT Trash Pump Trailer Mount Unit Specifications Suction x Discharge 6 x 6 in 152 x 152 mm Max. Water Capacity 1190 gpm 4522 lpm Max. Lift 25 ft 7.6 m Max. Head 111 ft 34 m Max. Pressure 48.9 psi 331 kPA Max. Solid Intake 3 in 76 mm Fuel Tank Capacity 28 Gal 106 L Notes: Trailer Mounted Dimensions & Weights Overall Length 101 in 2565 mm Overall Width 56 in 1422 mm Overall Height 68 in 11727 mm Operating Weight 1700 lb 77 kg

Multiquip MQ62TKT Trash Pump Trailer Mount SAFETY INFORMATION Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety messages and operating instructions could result in injury to yourself and others. SAFETY MESSAGES The four safety messages shown below will inform you about potential hazards that could injure you or others. The safety messages specifically address the level of exposure to the operator and are preceded by one of four words: DANGER, WARNING, CAUTION or NOTICE. SAFETY SYMBOLS DANGER Indicates a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS INJURY. WARNING Indicates a hazardous situation which, if not avoided, COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages. GENERAL SAFETY „ NEVER operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective devices required by the job or city and state regulations. „ NEVER operate this equipment when not feeling well due to fatigue, illness or when under medication. „ NEVER operate this equipment under the influence of drugs or alcohol. NOTICE „ This equipment should only be operated by trained and qualified personnel 18 years of age and older. „Whenever necessary, replace nameplate, operation and safety decals when they become difficult read. „ Manufacturer does not assume responsibility for any accident due to equipment modifications. Unauthorized equipment modification will void all warranties. „ NEVER use accessories or attachments that are not recommended by Multiquip for this equipment. Damage to the equipment and/or injury to user may result. „ ALWAYS know the location of the nearest fire extinguisher. „ ALWAYS know the location of the nearest first aid kit. „ ALWAYS know the location of the nearest phone or keep a phone on the job site. Also, know the phone numbers of the nearest ambulance, doctor and fire department. This information will be invaluable in the case of an emergency. PUMP SAFETY DANGER „ NEVER pump volatile, explosive, flammable or low flash point fluids. These fluids could ignite or explode. „ The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. „ The engine of this equipment requires an adequate free flow of cooling air. NEVER operate this equipment in any enclosed or narrow area where free flow of the air is restricted. If the air flow is restricted it will cause injury to people and property and serious damage to the equipment or engine. „ NEVER operate the equipment in an explosive atmosphere or near combustible materials. An explosion or fi re could result causing severe bodily harm or even death. WARNING „ NEVER pump corrosive chemicals or water containing toxic substances. These fluids could create serious health and environmental hazards. Contact local authorities for assistance. „ NEVER open the priming plug when pump is hot. Hot water inside could be pressurized much like the radiator of an automobile. Allow pump to cool to the touch before loosening plug. The possibility exists of scalding, resulting in severe bodily harm. „ NEVER operate the pump with closed discharge hose. The liquid could reach boiling temperatures, build pressure, and cause the casing to rupture or explode. „ NEVER disconnect any emergency or safety devices. These devices are intended for operator safety. Disconnection of these devices can cause severe injury, bodily harm or even death. Disconnection of any of these devices will void all warranties. CAUTION „ NEVER lubricate components or attempt service on a running machine. „ NEVER block or restrict flow from discharge hose. Remove kinks from discharge line before starting pump. Operation with a blocked discharge line can cause water inside pump to overheat. NOTICE „ ALWAYS fill the pump casing with water before starting the engine. Failure to maintain water inside the pump housing will cause severe damage to the pump and mechanical seal. „ In winter drain water from pump housing to prevent freezing. „ NEVER start the pump with the clean-out cover removed. The rotating impeller inside the pump can cut or sever objects caught in it. Before starting the pump, check that the clean-out cover is securely fastened. „ ALWAYS keep the machine in proper running condition. „ ALWAYS ensure pump is on level ground before use. „ Fix damage to machine and replace any broken parts immediately. „ ALWAYS store equipment properly when it is not being used. Equipment should be stored in a clean, dry location out of the reach of children and unauthorized personnel. ENGINE SAFETY WARNING „ DO NOT place hands or fingers inside engine compartment when engine is running. „ NEVER operate the engine with heat shields or guards removed. „ DO NOT remove the engine oil drain plug while the engine is hot. Hot oil will gush out of the oil tank and severely scald any persons in the general area of the pump. CAUTION „ NEVER touch the hot exhaust manifold, muffler or cylinder. Allow these parts to cool before servicing equipment. NOTICE „ NEVER run engine without an air filter or with a dirty air filter. Severe engine damage may occur. Service air filter frequently to prevent engine malfunction. „ NEVER tamper with the factory settings of the engine or engine governor. Damage to the engine or equipment can result if operating in speed ranges above the maximum allowable. FUEL SAFETY DANGER „ DO NOT start the engine near spilled fuel or combustible fluids. Fuel is extremely flammable and its vapors can cause an explosion if ignited. „ ALWAYS refuel in a well-ventilated area, away from sparks and open flames. „ ALWAYS use extreme caution when working with flammable liquids. „ DO NOT fill the fuel tank while the engine is running or hot. „ DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. „ Store fuel in appropriate containers, in well-ventilated areas and away from sparks and flames. „ NEVER use fuel as a cleaning agent. „ DO NOT smoke around or near the equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine BATTERY SAFETY (ELECTRIC START ONLY) DANGER „ DO NOT drop the battery. There is a possibility that the battery will explode. „ DO NOT expose the battery to open flames, sparks, cigarettes, etc. The battery contains combustible gases and liquids. If these gases and liquids come into contact with a flame or spark, an explosion could occur. WARNING „ ALWAYS wear safety glasses when handling the battery to avoid eye irritation. The battery contains acids that can cause injury to the eyes and skin. „ Use well-insulated gloves when picking up the battery. „ ALWAYS keep the battery charged. If the battery is not charged, combustible gas will build up. „ DO NOT charge battery if frozen. Battery can explode. When frozen, warm the battery to at least 61°F (16°C). „ ALWAYS recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gases. „ If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water. „ If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention. CAUTION „ ALWAYS disconnect the NEGATIVE battery terminal before performing service on the equipment. „ ALWAYS keep battery cables in good working condition. Repair or replace all worn cables. TRANSPORTING SAFETY CAUTION „ NEVER allow any person or animal to stand underneath the equipment while lifting. NOTICE „ Before lifting, make sure that the equipment parts are not damaged and screws are not loose or missing. „ For safe lifting and placement of the pump, utilize the lifting bail. „ ALWAYS shutdown engine before transporting. „ NEVER lift the equipment while the engine is running. „ Tighten fuel tank cap securely and close fuel cock to prevent fuel from spilling. „ Use one point suspension hook and lift straight upwards. „ DO NOT lift machine to unnecessary heights. „ ALWAYS tie down equipment during transport by securing the equipment with rope. „ Never allow any person or animal to stand underneath the equipment while lifting. TOWING SAFETY CAUTION „ Check with your local county or state safety towing regulations, in addition to meeting Department of Transportation (DOT) Safety Towing Regulations, before towing your equipment. „ Refer to MQ Power trailer manual for additional safety information. „ In order to reduce the possibility of an accident while transporting the equipment on public roads, ALWAYS make sure the trailer that supports the equipment and the towing vehicle are mechanically sound and in good operating condition. „ ALWAYS shutdown engine before transporting „ Make sure the hitch and coupling of the towing vehicle are rated equal to, or greater than the trailer “gross vehicle weight rating.” „ ALWAYS inspect the hitch and coupling for wear. NEVER tow a trailer with defective hitches, couplings, chains, etc. „ Check the tire air pressure on both towing vehicle and trailer. Trailer tires should be inflated to 50 psi cold. Also check the tire tread wear on both vehicles. „ ALWAYS make sure the trailer is equipped with a safety chain. „ ALWAYS properly attach trailer’s safety chains to towing vehicle. „ ALWAYS make sure the vehicle and trailer directional, backup, brake and trailer lights are connected and working properly. „ DOT Requirements (if applicable) include the following: • Connect and test electric brake operation. • Secure portable power cables in cable tray with tie wraps. „ The maximum speed for highway towing is 55 MPH unless posted otherwise. Recommended off-road towing is not to exceed 15 MPH or less depending on type of terrain. „ Avoid sudden stops and starts. This can cause skidding, or jack-knifing. Smooth, gradual starts and stops will improve towing. „ Avoid sharp turns to prevent rolling. „ Trailer should be adjusted to a level position at all times when towing. „ Raise and lock trailer wheel stand in up position when towing. „ Place chock blocks underneath wheel to prevent rolling while parked. „ Place support blocks underneath the trailer’s bumper to prevent tipping while parked. „ Use the trailer’s swivel jack to adjust the trailer height to a level position while parked. ENVIRONMENTAL SAFETY NOTICE „ Dispose of hazardous waste properly. Examples of potentially hazardous waste are used motor oil, fuel and fuel filters. „ DO NOT use food or plastic containers to dispose of hazardous waste. „ DO NOT pour waste, oil or fuel directly onto the ground, down a drain or into any water source.